2003 Japanrot/Naturbraun ZHP Touring Build

Touring VIN: WBAEN33483PC11790

Donor VIN: WBAEV53435KM08519 (ZHP1)

Donor VIN: WBAEV53474KM05542 (ZHP2)

Purchase mileage on touring: 

Donor engine mileage at time of transplant: 

List of changes from stock:

M54B30 Swap (ZHP1)

6-speed (ZHP2)

Natural Brown interior (ZHP1)

Front Subframe (ZHP1)

Steering Rack (ZHP2)

Front Control Arms (ZHP1)

Front Brakes (ZHP1)

Driveshaft (ZHP2)

Rear Differential (ZHP1)

Rear Subframe (ZHP1)

Rear Arms (ZHP1)

Rear Brakes (ZHP1)

Black cube trim (ZHP2)

List of updates/maintenance done:

Engine:

• BMW 5W30 Oil Change Kit - Liqui Moly 11427512300KT4 
• BMW DISA Valve - Rein 11617544805 
• BMW Oil Pressure Switch - Rein 12618611273
• BMW Timing Cover Plug - Reinz 11361433513
• BMW VANOS Unit Screw Plug - Genuine BMW 11361438338
• VANOS Overhaul
• Wiring Harness Engine Ignition 12517518044
• Air Inlet Assembly 13717501988
• Filler Cap - 16117222391
• Air Inlet Assembly Buffer - 07147267586
• Air Inlet Assembly Rivet - 51471919209
• Inlet Duct - 13717509118
• Tube - 13541438761
• Filler Cap - 11127509328
• Dipstick - 11431436293
• BMW Engine and Transmission Mount Kit - 22116779970KT1
• BMW Comprehensive Maintenance Kit - E46TUNEKIT2
• BMW Ignition Coil Kit (Set of 6) - Bosch 00044X6
• BMW Accessory Drive Belt Kit - 11287636379KT
• BMW M54 Timing Chain Kit - 11311432176KT1
• BMW Crankcase Gasket Set - Elring 11111432478
• BMW Engine Oil Filter Housing Gasket Kit - 11421719855KT
• BMW Intake Manifold Gasket Set - Elring 11611436631
• BMW 120 Amp Alternator - Bosch AL0703N
• BMW Starter Motor - Bosch 12412354693
• BMW Camshaft Position Sensor - VNE 12147539165
• BMW Camshaft Position Sensor - VNE 12147518628
• BMW Oil Level Sensor - Hella 12617508003
• BMW Crankshaft Position Sensor - VDO 12141709616
• BMW Ignition Knock Sensor - VDO 13627568422
• BMW Intake Boot - Rein 13541438759
• BMW Throttle Body Gasket - Elring 13547504729

Emissions:

• BMW Air Pump Rubber Mount - URO Parts 11727559515
• BMW Oxygen Sensor - Bosch 15109
• Pre-Cat Oxygen Sensor - Bosch
• BMW Secondary Air Injection Pump - Pierburg 11727553056
• BMW Secondary Air Injection Control Valve - Pierburg 11727553063
• BMW Secondary Air Pump Hose - Rein 11727555680
• BMW Air Pump Bracket - Genuine BMW 11721715273
• BMW Bracket - Genuine BMW 11721714230
• BMW Air Pump Rubber Mount - URO Parts 11727559515
• BMW Secondary Air Valve Vacuum Line - Rein 11727574490
• BMW Vacuum Hose - Genuine BMW 11657803732
• BMW Vacuum Control Valve - Genuine BMW 11747810831
• BMW Air Injection Check Valve - Pierburg 11611312737
• BMW Cold Climate PCV Breather System Kit - OE Supplier 11617533400KT3
• BMW Mass Air Flow Sensor O-Ring - Genuine 13541438760
• BMW Mass Air Flow Sensor

Cooling:

• BMW Comprehensive Cooling System Hose Kit (E46) - 11531436408KIT
• BMW Plastic Water Pump Pulley - Meyle 11511436590
• BMW Cooling System Overhaul Kit With Water Pump - E46COOLKIT

Brakes:

• Rear Brake Rotors - Zimmermann 34216864044KTR3
• Rear Brake Pads - Akebono
• BMW Brake Kit - Zimmermann/Akebono 330BK4
• Brake Master Cylinder - Centric 13034106
• BMW Brake Booster - ATE 34336779682 
• BMW Clutch Hydraulic Hose - Genuine BMW 35006857512 
• BMW Caliper Bracket Bolt - Genuine BMW 34116772428
• BMW Caliper Bracket Bolt - Genuine BMW 34203414763 Drivetrain / 
• BMW Brake Master Cylinder - ATE 34336785666 (failed and replaced with Centric Part)
• BMW Brake Reservoir - Genuine BMW 34326750798

Steering:

• Power Steering Reservoir Clamp Genuine BMW 32411092940
• BMW Power Steering Pressure Hose - Genuine BMW
• BMW Powering Steering Reservoir - Genuine BMW
• BMW Power Steering Return Hose - Genuine BMW
• BMW Power Steering Suction Hose - Genuine BMW
• BMW Power Steering Pressure Hose - Genuine BMW
• BMW Plastic Power Steering Pump Pulley - Febi 32421740858
• BMW Steering Coupling Assembly - Genuine BMW 32301094703

Suspension:

• Ground Control Coilovers
• Ground Control Camber Plates
• Ground Control RSM
• BMW Sway Bar Link - Genuine BMW

Interior: (all parts below brand new still in box)

• BMW Black Short Console - Genuine BMW 51168234154
• BMW Ash Tray Rear - Genuine BMW 51168225988 
• BMW Cup Holder Black - Genuine BMW 51168217953 
• BMW Console Coin Tray - Genuine BMW 51168217957 
• BMW Console Bracket - Genuine BMW 51168235570 
• Dynavin E46 HVAC Relocation Bracket with 2 USBs
• 2022 Eonon Quad Core Car Radio with IPS Display/GPS, Compatible with BMW 3 Series 1999-2004(E46), Built-in Apple CarPlay, Support Android Auto-9 Inch-GA9450B

Exterior / Body:

• M-tech Bumper Cover (Front) - 51-12-7-893-489
• M-tech Bumper Cover - Euro(Rear) - 51-11-7-893-328
• M-tech Rocker Molding - 51-71-2-693-225
• M-tech Rocker Molding - 51-71-2-693-226Molding - 51-11-8-195-289
• Molding - 51-11-8-195-290
• Center Molding - 51-11-8-195-304
• Cap - 51-11-7-893-378
• Lamp Cover - 51-11-7-893-067
• Lamp Cover - 51-11-7-893-068
• Lower Grille - 51-11-7-893-331
• Lower Grille Adapter - 51-11-7-893-324
• Bumper Cover Support - 51-11-7-895-415
• Bumper Cover Support - 51-11-7-895-416
• Bumper Cover Bracket - 51-11-8-191-149
• Outer Molding - 51-12-7-893-319
• Center Molding - 51-12-8-212-589
• Cover, Lower Part Center M - 51-12-7-891-916
• Water Deflector - 51-12-7-895-234
• Fog Lamp Assembly - 63-17-7-894-017
• Fog Lamp Assembly - 63-17-7-894-018
• Liner Extension - 51-71-8-265-467
• Liner Extension - 51-71-8-265-468
• Tow Eye Cap - 51-12-7-893-314
• Outer Molding - 51-12-7-893-320
• Tail Lamp Assembly - 63-21-6-900-473
• Tail Lamp Assembly - 63-21-6-900-474
• E46 Sedan/Wagon Windshield Cowl Grille - 51-71-8-208-483
• Vent Grille - 51-13-7-075-324
• Cowl Grille Clip - 51-71-8-234-698
• Roundel Emblem Replacement 82mm - 51-14-8-132-375BMW Hatch Lift Support - Stabilus 51248232873
• BMW Headlight Lens - Magneti Marelli 63126924045
• BMW Headlight Lens - Magneti Marelli 63126924046

Items done under my care:

• 2/4/23: subframe bushings replaced with Powerflex poly, diff bushings replaced with OE, axle bolts extracted and repaired, rear lower control arms replaced with Powerflex, all four brake lines replaced with Bimmerworld stainless, brake and clutch flush
• 2/10/23: new center console stack components, including cup holder, console, sunglass tray, and surround installed, completed black headliner installation
• 4/18/23: ZHP bumpers and side skirts painted and installed, window trims installed, upper window trims painted to match
• 4/28/23: 113,706mi. spark plugs (NGK BQR6EQUP), rear wheel bearings, new front air duct